Author Topic: My nose is loose  (Read 4133 times)

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
My nose is loose
« on: December 02, 2019, 04:07:06 pm »
B17
Love it to bits.
Recently the nut tightening up the saddle at the nose had startedd to unslacken.
I know I shouldn't over tighten it but even using the Brooks spanner or finger tightening it, doesn't work.
Should there be a second nut?
It leads to the nose being very wobbly.
Still feels great to ride though.
Never drink and drive. You may hit a bump  and spill your drink

geocycle

  • Hero Member
  • *****
  • Posts: 1318
Re: My nose is loose
« Reply #1 on: December 02, 2019, 07:28:52 pm »
Has it broken across the bend? Sheldon has a good picture of the bolt at the bottom of the repair page. https://www.sheldonbrown.com/saddle-repair.html


You can buy replacements or send it to brooks for a refurb.

https://www.sjscycles.co.uk/saddles-spares-care/
« Last Edit: December 02, 2019, 07:34:47 pm by geocycle »
 

ipswichcycler

  • Newbie
  • *
  • Posts: 49
Re: My nose is loose
« Reply #2 on: December 02, 2019, 09:05:25 pm »
Hi Matt2matt2002

Did my PM get through to you? I wasn’t sure if it sent.

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
Re: My nose is loose
« Reply #3 on: December 02, 2019, 10:31:21 pm »
Thanks
I'll take a proper look tomorrow
Perhaps post a picture.
Pretty sure no rails are broken.
Never drink and drive. You may hit a bump  and spill your drink

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
Re: My nose is loose
« Reply #4 on: December 03, 2019, 08:47:31 pm »
How does this look? No broken rails.
After tightening up the nut, it works loose after a few rides.
Should there be a washer or something on the opposite end of the bolt?
Never drink and drive. You may hit a bump  and spill your drink

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
Re: My nose is loose
« Reply #5 on: December 03, 2019, 08:49:35 pm »
Better pictures?
Never drink and drive. You may hit a bump  and spill your drink

Danneaux

  • Administrator
  • Hero Member
  • *****
  • Posts: 8229
  • reisen statt rasen
Re: My nose is loose
« Reply #6 on: December 03, 2019, 09:57:18 pm »
Hi Matt!

Please, can you post a photo showing the top of the saddle?

When I've run into similar tension problems on friends' saddles, the root cause was usually a sway-backed leather cover. When that happens, the leather stretches and it can become difficult to get the tension bolt to remain tight. No, there is no "extra" nut that is missing. The pitch of the threads is usually enough to hold tension unless some other condition obtains.

The tension bolt tensions the leather and if the leather is stretched, it may not exert enough counter-tension on the bolt threads to keep the nut tight.

The underside of yours does not look like a B.17 to me because of the extra rail "return" loop behind the tension cap. Is it instead a Flyer with springs at the rear, Matt?

It is also possible the tension cap has become unstaked from the leather nose. Check carefully to make sure all the rivets going through the leather and into the steel tension cap are intact and not just partially engaged. The same thing can happen at the cantle plate at the rear, but is generally more obvious.

When you do tension the saddle, use some care. It usually doesn't require much and overdoing it can cause tears if the leather is dried-out.

I've re-riveted a number of B.17 saddles with success and have even restored several that have become swaybacked after the owners rode them while the saddles were rain-soaked. It is best to remove the leather cover on those and soak in water before reshaping and carefully drying, but it can also be done in situ if the tension bolt is backed off all the way or (preferably) disengaged first.

Best,

Dan.
« Last Edit: December 04, 2019, 02:03:25 am by Danneaux »

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
Re: My nose is loose
« Reply #7 on: December 03, 2019, 10:24:49 pm »
Thanks Dan.
Pictures to follow soon.
Leather looks fine to me and nothing underneath adrift.
But I'll sure take a few more pictures.
Matt
Never drink and drive. You may hit a bump  and spill your drink

geocycle

  • Hero Member
  • *****
  • Posts: 1318
Re: My nose is loose
« Reply #8 on: December 04, 2019, 09:30:32 am »
The head of the tensioning bolt doesn't look square with the leather in your second picture.  It might just be the angle of the picture but I wonder if one of the rivets at the nose has broken?If all is intact then it probably just needs tensioning but as dan says it is best to do this slowly. 
 

Matt2matt2002

  • Hero Member
  • *****
  • Posts: 1893
Re: My nose is loose
« Reply #9 on: December 04, 2019, 11:31:57 am »
No rails or rivets broken
Never drink and drive. You may hit a bump  and spill your drink